Rear spoiler 9-5 4D 1

English

Delen op sociale netwerken

Koppeling delen

Gebruik permanente koppeling om te delen via sociale media

Deel met een vriend

Alstublieft in te loggen voor het versturen van deze document per e-mail!

In uw website insluiten

Kies de startpagina

2. 2 32 025 689 Saab 9-5 4D M06- 1 Spoiler 2 Zinc washer (x3) 3 Screw (x3) 4 Washer (x3) 5 Sealing strip 6 Template E980A518 4 3 1 2 6 5

1. Saab 9-5 4D M06- 900 Installation instructions SCdefault MONTERINGSANVISNING · INSTALLATION INSTRUCTIONS MONTAGEANLEITUNG · INSTRUCTIONS DE MONTAGE SITdefault Saab 9-5 4D M06- Rear spoiler Accessories Part No. Group Date Instruction Part No. Replaces 93 185 386 9:84-35 Sep 05 32 025 689 E980A517

3. 32 025 689 3 Saab 9-5 4D M06- The spoiler has been treated with primer and is ready for painting. 1 Paint the spoiler the same colour as the body, see “Instructions for painting preprimed PUR plastic“ in these installation instructions. 2 Open the boot lid. US/CA: Detach the emergency opening handle from the trim. 3 Remove the closing handle on the inside of the boot lid, the two-stage rivets and the boot lid trim. 4 US/CA: Pass the emergency opening handle through the opening in the trim. 5 Close the boot lid. E980A519 3 3

5. 32 025 689 5 Saab 9-5 4D M06- 13 Fit the sealing strip on the underside of the spoiler. 14 Open the boot lid. 15 Apply Loctite 242 Thread locking adhesive, to the screws. 16 Position the spoiler on the boot lid. 17 Insert the screws with washers. Check the fit of the spoiler 18 Tighten the centre screw. Tightening torque, centre screw, 7 Nm (5 lbf ft) 19 Tighten the outer screws. Tightening torque, outer screws, 2 Nm (1.5 lbf ft) Check the fit of the spoiler. 20 Clean off and vacuum all swarf. E980A521 13 17,19 17,18 17,19

6. 6 32 025 689 Saab 9-5 4D M06- 21 US/CA: Fit the emergency opening mechanism. 22 Fit the boot lid trim, the two-stage rivets and the closing handle. 23 US/CA: Fit the emergency opening handle. 24 Close the boot lid. Advise the customer that there is a risk of crushing. WARNING As the spoiler protrudes over the sides of the boot lid, there is a risk of crushing between the spoiler and the rear wings. E980A522 22 22

4. 4 32 025 689 Saab 9-5 4D M06- 6 Cut out the template in accordance with the markings. Position the template on the boot lid and secure it with several pieces of tape. 7 Mark out the holes using a centre punch. 8 Remove the template and tape. 9 Drill the outer holes in 3 stages. Drill in accord- ance with the following: · Stage 1: 3.5 mm drill bit · Stage 2: 6.5 mm drill bit · Stage 3: 9 mm drill bit 10 Drill the centre hole in 2 stages. Drill in accord- ance with the following: · Stage 1: 3.5 mm drill bit · Stage 2: 6.5 mm drill bit 11 Deburr the holes and remove loose drillings and flakes of paint. Clean with Teroson FL Cleaner. Apply Standox 1K Primer Filler. Apply finish paint. Apply Terotex HV 400 or Mercasol 1 cav- ity sealer to internal surfaces. 12 Fit the zinc washers on the new drilled holes. The zinc washers must be fitted on the outside of the boot lid. Important Check the position of the template and adjust as necessary. The measurements to the front edge of the boot lid must be equal on the right and left- hand sides. E980A520 6.5mm 3.5mm 9mm 6 9 6.5mm 3.5mm 10 12

7. 32 025 689 7 Saab 9-5 4D M06- Instructions for painting preprimed PUR-RIM plastic. · Clean the surfaces thoroughly. · During the painting process the spoiler should be placed in such a way that it will not be deformed. · The temperature must not exceed +40°C (104°F). · The spoiler is preprimed as delivered from the supplier. · Clean gloves should be worn when handling the spoiler. Drying time 70 minutes at +40°C (104°F). Preparations · For best results, pore-filling paint should be applied. · Rub down the primed surfaces thoroughly. Use 3M 1200 or 800 abrasive paper.

Weergaven

  • 1295 Totale weergaven
  • 1074 Websiteweergaven
  • 221 Ingesloten weergaven

Acties

  • 0 Gedeeld op sociale media
  • 0 Vind-ik-leuks
  • 0 Vind-ik-niet-leuks
  • 0 Opmerkingen

Aantal malen gedeeld

  • 0 Facebook
  • 0 Twitter
  • 0 LinkedIn
  • 0 Google+

Insluitingen 4

  • 14 saabpartners.com
  • 36 www.saabpartners.com
  • 2 52.29.207.161
  • 6 54.154.214.138